新闻详情

气体增压泵操作程序

1、气体增压泵将二联体的油雾器加入润滑油。南方用10#或20#机械油,北方冬季用防冻机械油或低凝液压油。连接上需要增压的管路,关闭卸荷阀,打开高压针阀,气源压力要求不大于0.6MPa(6kgf/cm2)。

1, gas booster pump to add two couplet of oil mist lubricating oil. South with # 10 or 20 # machine oil, north

winter with antifreeze machine oil or low condensate hydraulic oil. Need booster pipeline connection, close

unloading valve, open the high-pressure needle valve, air pressure to no greater than 0.6 MPa (6 KGF/cm2).

2、调整好二联体的压力,如将气源压力调到0.6MPa,增压后气体压力为1.2MPa。

2, adjust the second couplet body pressure, such as air pressure will be dispatched to 0.6 MPa, pressurized gas

pressure is 1.2 MPa.

3、储气罐出口装有安全阀,最高设定压力1.2MPa,当出口压力高于设定压力1.2MPa时,安全阀打开。

3, gasholder export is equipped with safety valve, the highest set pressure 1.2 MPa, when the outlet pressure is

higher than the set pressure is 1.2 MPa, the relief valve opens.

最大耗气量及配套的空压机

The largest gas consumption and form a complete set of air compressor

耗气量主要是由增压泵的驱动缸活塞的每分钟的往复次数所决定的,在所供气源压力不便的情况下,泵的往复次数决定于排出气体压力的大或小。当气源压力调至最高作空载排气时(如对被检大容积容器充气时)就是泵耗气量最大的时候。随着被试容器内的气压逐渐升高,泵的往复速度也逐渐减慢,直至驱动气气压与排气气压成比例平衡后,泵就停止工作,耗气量就等于零。该装置所配气体增压泵STA02的最大耗气量为1.2m3/min, 按照常规充气情况,可选0.7-1.2m3/min排量的空压机就可。

Gas consumption is mainly driven by the booster pump cylinder piston reciprocating frequency determined by the per

minute, for air pressure by the inconvenience of the cases, the number of reciprocating pump is determined by

discharge gas pressure of the big or small. When the air pressure switch to the highest for no-load exhaust (for

example, when to be big bulk container filling) is a time when pump's largest gas consumption. As the participants

container pressure increased, the reciprocating pump speed also gradually slow down, until the driver is

proportional to the gas pressure and exhaust air pressure balance, pump stop working, gas consumption is equal to

zero. The device is the largest gas consumption of gas booster pump STA02 is 1.2 m3 / min, according to the

conventional aeration condition, the optional 0.7 1.2 m3 / min displacement compressor.

BACK
map
联系我们:
江苏省恒光屏蔽泵有限公司
电话:
0523-527638
邮箱:
rhjfpxixy@healthy-superstore.com

版权所有:江苏省恒光屏蔽泵有限公司, All rights reserved

地址:江苏省泰州市  电话:0523-527638  邮箱: rhjfpxixy@healthy-superstore.com